• flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    A typical flow sheet involves either the direct anionic flotation of hematite or the reverse cationic/anionic flotation of silica gangue, and is preceded by a desliming stage to reduce the detrimental impact of particles finer than 20 μm on overall recoveries (Filippov et al., 2014, Ma, 2012). The slimes do not usually undergo further

  • flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    Anionic PNIPAM as a selective flocculant/collector for iron ore flotation. • PNIPAM has improved recoveries and grades in the mids/coarse. • Turbidity testing confirms the flocculation of fines with PNIPAM. • PNIPAM has better recovery but poor grades in the fines due to gangue entrapment. •

  • flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic temperature-responsive polymer acting as a selective flocculant and collector Article in Minerals Engineering 77 · June 2015 with 66 Reads

  • flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    2015-06-01· Read "Flocculation/flotation of hematite fines with anionic temperature-responsive polymer acting as a selective flocculant and collector, Minerals Engineering" on DeepDyve, the largest online rental service for scholarly research with thousands of academic publications available at

  • flocculation and flotation characteristics of fine

    Flocculation and flotation characteristics of fine

    Flocculation and flotation characteristics of fine hematite with sodium oleate have been investigated through electrophoretic mobility, surface hydrophobic properties, adsorption measurement

  • flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    Journal article. Flocculation/flotation of hematite fines with anionic temperature-responsive polymer acting as a selective flocculant and collector

  • reverse flotation separation of hematite from quartz

    Reverse flotation separation of hematite from quartz

    2019-08-01· Researchers have tried to improve flotation of fine hematite particles by enlarging their apparent sizes through aggregation, carrier flotation, selective flocculation, and hydrophobic (shear) flocculation (Qiu et al., 1993, Shibata and Fuerstenau, 2003, Forbes, 2011).

  • selective flocculation and flotation

    Selective Flocculation and Flotation

    Methods for upgrading the fine-grained oxidized taconites found in the Michigan and Minnesota iron ranges include the selective flocculation-gangue flotation system using either an anionic or a cationic collector. After extensive research and development on the two flotation systems, the cationic flotation process was determined to be the

  • flocculation of fine hematite and quartz suspensions with

    Flocculation of fine hematite and quartz suspensions with

    Anionic nanofibers were tested in flocculation of hematite and quartz suspensions. • Anionic nanofibers did not flocculate quartz but flocculated hematite. • Flocculation efficiency was affected by suspension pH and type of anionic nanofiber. • Kinetics of flocculation and floc strength dependent on the type of nanofiber.

  • flocculation of fine hematite and quartz suspensions

    Flocculation of fine hematite and quartz suspensions

    Request PDF Flocculation of fine hematite and quartz suspensions with anionic cellulose nanofibers Research was undertaken to investigate the efficiency of anionic

  • flocculation/flotation of hematite fines with anionic

    Flocculation/flotation of hematite fines with anionic

    Journal article. Flocculation/flotation of hematite fines with anionic temperature-responsive polymer acting as a selective flocculant and collector

  • selective flocculation separation of fine hematite

    Selective Flocculation Separation of Fine Hematite

    flocculation of fine hematite, and the mechanism in the separation of fine hematite from quartz was illustrated through particle size tests, zeta potential measurements and adsorption tests. 2. Materials and Methods 2.1. Samples and Reagents Pure hematite samples (TFe grade: 67.72%) were obtained from Luanxian County, Hebei, China,

  • floatation of hematite teensbasketcossato.it

    floatation of hematite teensbasketcossato.it

    Hydrophobic Bacteria Hematite Flotation Surface Chemistry of Mycobacterium phleiBacterial Adhesion ExperimentsFlotation ExperimentsAdhesion of MicroorganismPotential Energy of Interaction M. phlei is a gram-positive procaryotic cell. It has a rod like shape with 1-1.5 µm in diameter and 5 µm in length.

  • agglomerate flotation of fine oxide particles request

    Agglomerate flotation of fine oxide particles Request

    Agglomerate flotation of fine oxide particles . Article in International Journal of Mineral Processing 74(1-4):85-90 · November 2004 with 208 Reads How we measure 'reads' A 'read' is counted each

  • shear hydrophobic flocculation and flotation

    Shear hydrophobic flocculation and flotation

    Shear hydrophobic flocculation and flotation of ultrafine Anshan hematite using sodium oleate Article in Transactions of Nonferrous Metals Society of China 21(3):652-664 · March 2011 with 30 Reads

  • selective flocculation separation of fine hematite

    Selective Flocculation Separation of Fine Hematite

    Furthermore, the selective flocculation separation was confirmed in the mixed mineral flocculation. From adsorption tests and zeta potential measurements, it is shown that GCF tended to adsorb more selectively and intensely on hematite surfaces compared with quartz. This study provides a valuable reference for the efficient recovery of fine

  • depressants and flocculants in iron ore beneficiation

    Depressants and Flocculants in Iron Ore Beneficiation

    This article discusses the effect of physical and chemical modifications of starches on the anionic and cationic flotation of silica from oxidized iron ores and magnetite-taconite concentrates, and the results of the interaction of starch, pH, and calcium ions on the flocculation, clarification, and filtration of iron ore slimes and magnetite- taconite tailings.

  • selective flocculation separation of fine hematite

    Selective Flocculation Separation of Fine Hematite

    Furthermore, the selective flocculation separation was confirmed in the mixed mineral flocculation. From adsorption tests and zeta potential measurements, it is shown that GCF tended to adsorb more selectively and intensely on hematite surfaces compared with quartz. This study provides a valuable reference for the efficient recovery of fine

  • froth flotation of iron ores publications

    Froth Flotation of Iron Ores Publications

    Froth Flotation of Iron Ores Mark Ma CSIRO Process Science and Engineering, Box 312, Clayton, Victoria, 3169, Australia Abstract With the depleting reserves of high-grade iron ore in the world, froth flotation has become increasingly important to process intermediate- and low-grade iron ore in an attempt to meet the rapidly growing demand on the

  • selective flocculation of fines columbia university

    SELECTIVE FLOCCULATION OF FINES Columbia University

    SELECTIVE FLOCCULATION OF FINES by P. Somasundaran' ABSTRACT Selective flocculation, followed by a conventional mineral processing technique such as flotation, e1utriation, or sedimentation, is a promising technique for the beneficiation of mineral slimes. In this paper, a review of basic chemical and hydrodynamical aspects of dispersion, flocculation, and selective flocculation is presented

  • floatation of hematite fotoflexveendam.nl

    Floatation Of Hematite fotoflexveendam.nl

    Shear flocculation and flotation of hematite . DeepDyve. Read "Shear flocculation and flotation of hematite using sodium oleate, International Journal of Mineral Processing" on DeepDyve, the largest online rental service for scholarly research with thousands of academic publications available at

  • flocculation of hematite fines by anionic polyacrylamide

    Flocculation of hematite fines by anionic polyacrylamide

    : Flocculation studies on iron-ore fines (size < 10 mum) were conducted using three anionic polyacrylamide polymers over the pH range 4.0 10.0 and flocculant dosages up to 0.20 kg/ton. The flocculation was favourable under acidic conditions and was helped substantially by CaCl2 additions in alkaline conditions. Zeta potential measurements indicated a specific adsorption of polymers.

  • flotation of iron oxides and quartz—a review: mineral

    Flotation of Iron Oxides and Quartz—A Review: Mineral

    2010-06-10· The diverse effect of temperature on iron oxides and calcium-activated quartz flotation is also indicated; the flocculation-flotation process of upgrading fine-grained iron ores is highlighted; and the economic advantage of reverse flotation in high grade, coarse- or medium grained iron ore flotation

  • 1 introduction puc-rio

    1 Introduction PUC-Rio

    flotation routes developed for iron ores, currently, the reverse cationic flotation route developed by the USBM branch in Minnesota is by far the most widely used flotation route in the iron ore industry. The two anionic flotation routes developed by Hanna Mining and Cyanamid, i.e. direct anionic flotation and reverse anionic flotation routes

  • minerals free full-text a study on the flocculation

    Minerals Free Full-Text A Study on the Flocculation

    Polyacrylamide (PAM) and derivative products are well-known flocculants widely applied in various fields, such as wastewater treatment [1,2], fine sedimentation [3,4], and agglomeration flotation [] in mineral processing.There are three main types of PAM: anionic, cationic, and nonionic, and amongst them, the anionic PAM (APAM) usually exhibits a strong flocculating effect and has been used

  • froth flotation of iron ores sapub

    Froth Flotation of Iron Ores sapub

    The two anionic flotation routes developed by Hanna Mining and Cyanamid, i.e. direct anionic flotation and reverse anionic flotation routes, are also being used in the iron ore industry. The history of iron ore flotation started with direct flotation of iron oxides using anionic collectors such as petroleum sulphonate, fatty acids and hydroxamates.

  • effect of particle size on flotation performance of hematite

    Effect of particle size on flotation performance of hematite

    anionic flotation were described by Araújo et al. (2005). In China, anionic flotation is often employed according to iron ore characteristic and technological conditions (Chen and Zhang, 2013). For direct flotation, hematite can be floated with fatty acid as collector, while silicate minerals are depressed. For the reverse flotation, hematite

  • minerals free full-text a study on the flocculation

    Minerals Free Full-Text A Study on the Flocculation

    Polyacrylamide (PAM) and derivative products are well-known flocculants widely applied in various fields, such as wastewater treatment [1,2], fine sedimentation [3,4], and agglomeration flotation [] in mineral processing.There are three main types of PAM: anionic, cationic, and nonionic, and amongst them, the anionic PAM (APAM) usually exhibits a strong flocculating effect and has been used

  • flocculation of kaolinite clay suspensions using a

    Flocculation of kaolinite clay suspensions using a

    The full text of this article hosted at iucr.org is unavailable due to technical difficulties.

  • adsorption of pregelatinized starch for selective

    Adsorption of Pregelatinized Starch for Selective

    Pregelatinized starch (PS) was used for the selective flocculation and flotation of fine siderite in carbonate-containing iron ore. With PS, the flotation of fine siderite was improved. The repulsive forces between fine siderite particles and the attractive forces between siderite and hematite or quartz were decreased after treated with PS, indicating the aggregation of siderite was enhanced

  • flocculation

    Flocculation

    Flocculation, in the field of chemistry, is a process in which colloids come out of suspension in the form of floc or flake, either spontaneously or due to the addition of a clarifying agent. The action differs from precipitation in that, prior to flocculation, colloids are merely suspended in a liquid and not actually dissolved in a solution

  • adsorption of pregelatinized starch for selective

    Adsorption of Pregelatinized Starch for Selective

    Pregelatinized starch (PS) was used for the selective flocculation and flotation of fine siderite in a carbonate-containing iron ore. With PS, the flotation of fine siderite was improved. The repulsive forces between fine siderite particles and the attractive forces between siderite and hematite or quartz were decreased after treatment with PS, indicating that the aggregation of siderite was

  • influence of coarse tailings on flocculation settlement

    Influence of coarse tailings on flocculation settlement

    Article Navigation > International Journal of Minerals, Metallurgy and Materials > 0 > Accepted Manuscript. Cite this article as:

  • hydrophobic flocculation flotation of rutile fines

    Hydrophobic flocculation flotation of rutile fines

    recognized as one of the most suitable methods for fine particle flotation. There have also been a great number of reports on other fine mineral particles using hydrophobic flocculation technology. Hematite fines, for instance, have been induced by anionic temperature-responsive polymer [19], talc fines by kerosene [20], marmatite

  • flotation behavior of hematite fines flocculated with

    Flotation behavior of hematite fines flocculated with

    Separation of a hematite-quartz mixture can be achieved by SDS flotation of PAA-flocculated hematite. Maximum selectivity results with the addition of small quantities of PAA, while excess polymer is detrimental to the recovery of hematite. Consecutive flotation states on a single feed yield a higher grade hematite product at some expense to the overall recovery.

  • flotation of hematite ore loof-amsterdam.nl

    flotation of hematite ore loof-amsterdam.nl

    Kaolinite and hematite flotation separation using etheramine and ,- flotation of hematite ore ,7 Nov 2012,Froth flotation Kaolinite Hematite a b s t r a c t Clay minerals are widespread in various types of mineral,There is a wide knowledge about separation of quartz from iron ore Despite the fact that quartz and kaolinite belong.3 Literature review Maxwell PUC-RioHematite or Frother

  • hematite flotation tailing schulpraxis.ch

    Hematite Flotation Tailing schulpraxis.ch

    Reverse flotation separation of hematite from quartz Aug 01, 2019· As of today, very little is known about magnetic aggregation in the flotation process of hematite. Therefore, in this work, the effect of selective magnetic aggregation on the flotation of fine hematite from quartz was investigated using simulated pulp with added minerals.

Related Post